2007 KAWASAKI NINJA 650R OWNERS MANUAL PDF

View and Download Kawasaki Ninja R service manual online. Ninja R Motorcycle pdf manual download. Also for: Ninja er-6f, Ninja er-6f abs. Visit Kawasaki Motor Corps., USA owners center for up to date service manuals, parts diagrams, ROK™ info, owner support, warranty info, Kawasaki Protection. Ninja R. ER-6f. ER-6f ABS. Motorcycle. Service Manual. All rights reserved. No parts of this publication may be reproduced, stored in a retrieval system, or.

Author: Jull Faelmaran
Country: Bulgaria
Language: English (Spanish)
Genre: Marketing
Published (Last): 21 June 2005
Pages: 347
PDF File Size: 15.18 Mb
ePub File Size: 12.17 Mb
ISBN: 151-4-68464-822-4
Downloads: 69987
Price: Free* [*Free Regsitration Required]
Uploader: Juzragore

Follow the specified tightening sequence. Such mahual shock to the water temperature sensor can damage it. Run the frame ground lead to outside of the other leads.

Direction of Engine Rotation When rotating the crankshaft by hand, the free play amount of rotating direction will affect the adjustment. Align the clamp knob with the red paint as shown in the figure.

Water-proof Joint C 3. Also, check to see that each cotter pin is in place and in good condition.

In addition, the condition of the problem is stored in the memory of the ECU electronic control unit. Page Also, permanent internal repairs have the advantage pwners permitting a thorough examination for secondary damage not visible from external inspection of the tire.

  BC817 40LT1G PDF

Run the brake hose into the guide. Install the shim specified where the lines intersect.

Kawasaki Ninja R Service Manual – ZX6R Forum

If they are badly worn or if there are groove cuts where the tangs hit, replace the housing. First turn the cap counterclockwise to the first stop. Stick coil trouble Inspect see chapter Page Apply silicone sealant to the portions [E] on the upper crankcase half, and insert [F] the new oil plug until it is bottomed. Replace the caliper if the cylinder and piston are badly scores or rusty. The thermostat is a wax pellet type which opens or closes with coolant temperature changes.

Do not touch the spark plugs or stick coils while the engine is running, or you could receive a severe electrical shock.

2007 Kawasaki Ninja 650R — Owner’s Manual

Clamp Hold the main harness, and insert the clamp into the battery case. Such a shock to the sensor can damage it. Insert the Kawasaki diagnostic system connector to the bracket.

ABS Self-diagnosis Terminal Kawasakk Tools and Sealant Hand Tester: Reserve Tank Over Flow Hose 4. Engine Stop Switch If the light does not go on, inspect or replace the following item. Front Ownegs Oil Seal Driver: Main Fuse 30 A 7.

Type Semi-sealed beam Bulb: If the fan does not rotate, the fan motor is defective and must be replaced. Front Wheel Rotation Sensor Torque – Clutch Spring Bolts: Inlet Air Temperature Sensor Fuel Pressure Gauge Adapter: Steering Stem Bearing Driver, Throttle Cable Decelerator 4.

  FAIREY OVERDRIVE MANUAL PDF

2007 Kawasaki Ninja 650R Owner’s Manual PDF

Gaskets, O-rings, oil seals, grease seals, circlips or cotter pins must be replaced with new ones whenever disassembled. Striking the rotor can cause the magnets to lose their magnetism. Clamp Faces the stopper forward. Replace the ABS hydraulic unit if any of them are cracked, or otherwise damaged.

If bearing play, roughness, or binding is ownegs, replace the bearing. Sealant – Kawasaki Bond Silicone Sealant: Table of Contents Add to my manuals Add. All information contained in this publication is based on the latest product information available at the time of publication. Clamp Insert clamp into the frame.

Be alert for problems and non-scheduled ticular interest for more efficient and con- maintenance. Don’t have an account? Special Tools and Sealant